Maintenance Manual.pdf - 第232页

AV131 MAINTENANCE MANUAL 11.1 M aterial Saf ety Data Sheet D79MEC- 4E-010-A 0 1 1. 1-17  Precautions in Ha ndling and St orage  Handlin g Techn ical counter measur es Handle i n well-v entilat ed p l ace. Pre v en t le…

100%1 / 244
AV131
MAINTENANCE MANUAL
11.1 Material Safety Data Sheet
D79MEC-4E-010-A0
11.1-16
11.1.8 Multemp LRL No.3
Oil name: Multemp LRL No.3
Manufacturer’s name: Kyodo Yushi Co., Ltd.
First Aid Measures
Eye contact
Immediately flush with plenty of clear water for at least 15 minutes. Consult a physician.
Skin contact
After wiping off the contacted area, flush abundantly with soap and water.
Inhalation
Remove to fresh air. Warm with blankets or other means and repose. Consult a physician if necessary.
Ingestion
Do not induce vomiting. Promptly consult a physician. Wash out mouth with water.
Fire Fighting Measures
Fire extinguishing agents
Foam, dry chemical, carbon dioxide, and dry sand.
Things should not be done
Water spray can spread fire and hazardous situation may result.
Specific fire fighting measures
For fires at earlier stage, use dry chemical, carbon dioxide or dry sand to douse.
For large fires, it is effective to use fire foam to block off air.
Evacuate unauthorized individuals to a safe place.
Protecting the fire fighter
Wear the protective gears.
Approach from upwind of fire.
Accidental Release Measures
Precaution for human body
Be sure to wear the protective gears.
Precaution for environmental protection
Be careful not to allow leaked grease enter to the river, etc.
How to clean up leakage
Collect leaked grease in an airtight container.
Small amount of leakage can be wiped away with flux such as kerosene.
Preventive measures against second disaster
Remove all ignition sources immediately.
AV131
MAINTENANCE MANUAL
11.1 Material Safety Data Sheet
D79MEC-4E-010-A0
11.1-17
Precautions in Handling and Storage
Handling
Technical countermeasures
Handle in well-ventilated place. Prevent leaks, overflows and scattering. Do not evaporate unnecessarily.
Precautions
Contact with eye may cause inflammation. Use protective glasses to prevent eye contact.
Contact with skin may cause inflammation. Use protective gloves to prevent skin contact.
Inhalation may lead to diarrhea or vomiting.
Seal off the container each time after use.
Safety handling precaution
When opening the container, wear gloves to protect hands against injury.
Storage
Appropriate storage condition
Seal off to store, to prevent dust and moist to get mixed in.
Avoid direct sunlight. Keep away from fire and heat source and store in dark place.
Safe packaging container material
Do not pressurize empty containers.
Do not weld, heat, drill or cut containers. Residue can catch fire with an explosion.
Disposal Consideration
Remaining waste
Dispose of properly in accordance with the law on waste disposal and cleaning.
Entrust the disposal to the specialists approved by the governor or to the local authorities responsible.
Do not dump into any sewers, on ground, or into any body of water.
Burn in an incinerator before disposing of in a landfill. Burnt residue must be below the criteria
stipulated by the relevant authorities.
Burn in a safe place in a manner where there is no possibility of hazard to others or damage to
properties. A guard must be placed.
Contaminated containers and packaging
Dispose of empty containers after cleaning the contents completely.
AV131
MAINTENANCE MANUAL
11.1 Material Safety Data Sheet
D79MEC-4E-010-A0
11.1-18
11.1.9 SYNTHESO HT320
Oil name: STNTHESO HT320
Manufacturer’s name: NOK Kluber Corporation
First Aid Measures
Inhalation
If inhaled excessively, remove to fresh air, warm with blankets or other means and repose. Consult a
physician if necessary.
Eye contact
Flush with plenty of clear water for at least 15 minutes. Consult a physician if necessary.
Skin contact
Wipe off attached grease and flush contacted areas abundantly with soap and water.
Consult a physician promptly, if itchiness or inflammation is found.
Ingestion
Do not induce vomiting. Promptly consult a physician.
Fire Fighting Measures
Fire extinguishing agents
Loaded stream fire extinguisher, foam, carbon dioxide and dry chemical.
Do not use water jet.
Specific fire fighting measures
Put out the source of fire. Wear protective gears.
Protection for fire fighters
Use a respirator to avoid inhaling harmful gas. Approach from upwind of the fire.
Accidental Release Measures
Precaution for human body
Wear protective gears to prevent exposure, inhalation of vapor and contact with skin.
Well-ventilate the room if necessary.
Prevent unauthorized entry to the leakage area.
Remove all ignition sources, hot objects, and inflammable material. Prepare a fire extinguisher.
Precaution for environmental protection
To prevent drainage containing this product from discharging to public water or seeping underground, do not
wash away the spillage on the floor.
How to clean the oil
For a small leak, collect the oil by using a spatula or a shovel, or soak into soil etc. Then wipe with waste
cloth completely.
Use safety appliances without sparks.
For a large leak, first prevent spreading by using earth and sand, and then collect the oil.